Hyundai Santa Fe (TM): Suspension System / Troubleshooting

Hyundai Santa Fe (TM) 2019-2023 Service and Repair Manual / Suspension System / Troubleshooting

Troubleshooting
Symptom
Possible cause
Remedy
Hard steering
 Improper front wheel alignment
 Correct
Excessive turning resistance of lower arm ball joint
 Replace
Low tire pressure
 Adjust
No power assist
 Repair and replace
Poor return of steering wheel to center
 Improper front wheel alignment
 Correct
Poor or rough ride
 Improper front wheel alignment
 Correct
Malfunctioning shock absorber
 Repair or replace
Broken or worn stabilizer
 Replace
Broken or worn coil spring
 Replace
Worn lower arm bushing
 Replace the lower arm assembly
Abnormal tire wear
 Improper front wheel alignment
 Correct
Improper tire pressure
 Adjust
Malfunctioning shock absorber
 Replace
Wandering
 Improper front wheel alignment
 Correct
Poor turning resistance of lower arm ball joint
 Repair
Loose or worn lower arm bushing
 Retighten or replace
Vehicle pulls to one side
 Improper front wheel alignment
 Correct
Excessive turning resistance of lower arm ball joint
 Replace
Broken or worn coil spring
 Replace
Bent lower arm
 Repair
Steering wheel shimmy
 Improper front wheel alignment
 Correct
Poor turning resistance of lower arm ball joint
 Replace
Broken or worn stabilizer
 Replace
Worn lower arm bushing
 Replace
Malfunctioning shock absorber
 Replace
Broken or worn coil spring
 Replace

Wheel and tire diagnosis
Rapid wear at the center
 Rapid wear at both shoulders
 Wear at one shoulder

•
Center-tread down to fabric due to excessive over inflated tires
•
Lack of rotation
•
Excessive toe on drive wheels
•
Heavy acceleration on drive
•
Under-inflated tires
•
Worn suspension components
•
Excessive cornering speeds
•
Lack of rotation
•
Toe adjustment out of specification
•
Camber out of specification
•
Damaged strut
•
Damaged lower arm
Partial wear
 Feathered edge
 Wear pattern

•
Caused by irregular burrs on brake drums
•
Toe adjustment out of specification
•
Damaged or worn tie rods
•
Damaged knuckle
•
Excessive toe on non-drive wheels
•
Lack of rotation

    Special Service Tools Tool (Number and Name) IIIustration Use 0K546-F6100 Shock absorber lock nut removal tool Used for remove the front shock absorber lock nut 09546-S1100 Shock absorber lock nut removal tool Used for remove the rear shock absorber lock nut

    Components and components location Components Location 1. Front sub frame 2. Drive shaft 3. Steering gear box 4.

    Other information:

    Hyundai Santa Fe (TM) 2019-2023 Service and Repair Manual: Photo Sensor. Description and operation

    Description The photo sensor is located at the center of the defrost nozzles. The photo sensor contains a photovoltaic (sensitive to sunlight) diode. The solar radiation received by its light receiving portion, generates an electromotive force in proportion to the amount of radiation received which is transferred to th

    Hyundai Santa Fe (TM) 2019-2023 Service and Repair Manual: Heater

    Heater Unit. Components and components location Component Location 1. Heater Unit Assembly Components 1. Heater unit assembly 2. Heater NVH pad 3. Heater seal duct 4.

    Categories

     
    Copyright © 2026 www.hsafe4.com - 0.0215