Hyundai Santa Fe (TM): Fuel Filler Door / Repair procedures

Hyundai Santa Fe (TM) 2019-2023 Service and Repair Manual / Body (Interior and Exterior) / Fuel Filler Door / Repair procedures

Replacement
  
•
Put on gloves to prevent hand injuries.
  
•
When removing with a flat-tip screwdriver or remover, wrap protective tape around the tools to prevent damage to components.
1.
Open the fuel filler door (A).
2.
Remove the luggage side trim.
(Refer to interior trim - "Luggage Side Trim")
3.
Loosen the mounting nuts and remove the luggage cover (A).
4.
Separate to fuel filler door cable (B) from fuel door actuator (A).
5.
Separate to fuel filler door cable (A).
6.
Using a screwdriver or remover, remove the fuel filler door (A).
7.
To install, reverse removal procedure.
  
•
Make sure the fuel filler door locks/unlocks and opens/closes properly.
•
Replace any damaged clips (or pin-type retainers).

    Component Location 1. Fuel Filler Door

    Other information:

    Hyundai Santa Fe (TM) 2019-2023 Service and Repair Manual: PTC Heater (Diesel only). Repair procedures

    Inspection Operating Logic Test (Manual only) Inspect the PTC operation with the confirmation logic below : 1. Entering (1) Set the mode to FLOOR. (2) Set the temperature to MAX HOT.

    Hyundai Santa Fe (TM) 2019-2023 Service and Repair Manual: Warning Indicator. Components and components location

    Categories

     
    Copyright © 2025 www.hsafe4.com - 0.015