Hyundai Santa Fe: Cruise Control System (CC) / Cruise Control (CC) Switch. Repair procedures

Hyundai Santa Fe (TM) 2019-2025 Service Manual / Advanced Driver Assistance System (ADAS) / Cruise Control System (CC) / Cruise Control (CC) Switch. Repair procedures

Inspection

Check for resistance between terminals in left switch position.

[Audio/Bluetooth]

Switch	Connector terminal	Resistance (± 3%)
SEEK Up	1 - 6	430 Ω
SEEK Down	1 - 6	1.1 kΩ
MODE	1 - 6	2.11 kΩ
MUTE	1 - 6	3.11 kΩ
Volume up	1 - 6	4.61 kΩ
Volume down	1 - 6	6.81 kΩ
Voice	1 - 6	10.71 kΩ
END	1 - 6	18.91 kΩ
SEND	1 - 6	40.91 kΩ

Check for resistance between terminals in right switch position.

[Trip/Cruise]

Switch	Connector terminal	Resistance (± 3%)
CANCEL	2 - 6	390 Ω
SET (-)	2 - 6	610 Ω
RES (+)	2 - 6	910 Ω
Cruise ON/OFF	2 - 6	1.38 kΩ
Cruise Mode	2 - 6	2.13 kΩ
Smart Cruise	2 - 6	3.63 kΩ
Trip Group	1 - 6	390 Ω
Trip Up	1 - 6	610 Ω
Trip Down	1 - 6	910 kΩ
Trip OK	1 - 6	1.38 kΩ

Removal

1.	Disconnect the negative (-) battery terminal.

2.	Remove the driver airbag module. (Refer to Restraint - "Driver Airbag (DAB) Module and Clock Spring")

3.	Remove the steering wheel. (Refer to Steering System - "Steering Column and Shaft")

4.	Remove the steering wheel cover (A) after loosening the screws.

5.	Loosen the screws and then disconnect the steering wheel remote control switch connector.

6.	Remove the remote control switchs (A).

Installation

1.	Install the remote control switch on the steering wheel.

2.	Install the steering wheel.

Reconnect the remote control switch connector and airbag connectors.

Make sure that the switch connector is plugged in properly.

4.	Install the driver airbag module.

5.	Connect the negative (-) battery terminal.

Cruise Control (CC) Switch. Schematic diagrams

Rear View Monitor (RVM)

Other information:

Hyundai Santa Fe (TM) 2019-2025 Service Manual: Direct Electro Hydraulic Actuator Coupling. Repair procedures

Inspection • All units are filled up with coupling fluid (ultra-low viscosity ATF) prior to shipping. Inspection, fill-up, and replacement of coupling fluid is therefore not necessary (zero maintenance, lifetime fluid)...

Hyundai Santa Fe (TM) 2019-2025 Service Manual: Repair procedures

Removal • Put on gloves to prevent hand injuries. • Use seat covers to avoid damaging any surfaces...