Hyundai Santa Fe: Fuel Delivery System / Fuel Pump Motor. Repair procedures

Hyundai Santa Fe (TM) 2019-2025 Service Manual / Engine Control/Fuel System / Fuel Delivery System / Fuel Pump Motor. Repair procedures

Removal
1.
Remove the fuel pump.
(Refer to Fuel System - "Fuel Pump")
2.
Disconnect the fuel sender connector (A).

3.
Release the fixing hook (A) and then remove fuel sender (B) in the arrow direction.

4.
Remove the fixing pin (A) and then disconnect the fuel feed tube (B).

5.
Disconnect the fuel pump motor connector (A).

6.
Release the fixing hook (A) and then remove the head assembly (B).

7.
Release the fixing hook (A) and then remove the reservoir-cup (B).

8.
Disconnect the fuel pump motor connector (A).
9.
Disconnect the ground cable (B).

10.
Remove the fixing pin (A) and then disconnect the fuel pressure regulator (B).

11.
Release the fixing hook and then remove the assist pump (A).

12.
Separate the fuel pump hose (A) after releasing the clamp (B).

  
Replace the clamp with a new one when reinstalling the clamp.
13.
Remove the pump filter & fuel pump (A) after releasing the hooks.

Installtion
1.
Install in the reverse order of removal.

    Fuel Filter. Repair procedures

    Removal 1. Remove the fuel pump. (Refer to Fuel System - "Fuel Pump") 2. Disconnect the fuel sender connector (A)...

    Fuel Sender. Repair procedures

    Removal 1. Remove the fuel pump. (Refer to Fuel System - "Fuel Pump") 2. Disconnect the fuel sender connector (A)...

    Other information:

    Hyundai Santa Fe (TM) 2019-2025 Service Manual: Repair procedures


    Removal 1. Disconnect the negative (-) battery terminal. 2. Remove the cover (A) by using a flat-tip screwdriver. 3. Disconnect the connector (A) and then remove the occupant alert sensor...

    Hyundai Santa Fe (TM) 2019-2025 Owner's Manual: Rear window defroster


    NOTICE To prevent damage to the rear window defroster conducting elements bonded to the inside surface of the rear window, never use sharp instruments or window cleaners containing abrasives to clean the window. The defroster heats the window to remove frost, fog and thin ice from the interior and exterior of the rear window, while the engine is running...

    Categories

    Engine oil pressure warning light. Low fuel level warning light

    Engine oil pressure warning light

    This warning light illuminates:

    When the engine oil pressure is low.

    If the engine oil pressure is low:

    1. Drive carefully to the nearest safe location and stop your vehicle.

    2. Turn the engine off and check the engine oil level (For more details, refer to “Engine Oil” section in chapter 9). If the level is low, add oil as required.

    read more


     
    Copyright © 2025 www.hsafe4.com